Tips To Help Winterize Your ATV/UTV

//Tips To Help Winterize Your ATV/UTV

Tips To Help Winterize Your ATV/UTV

Winter is coming, so we will be talking about some tips to help you winterize your ATV, UTV, RTV, or Side By Side in this article. If you plan on driving your rig any this winter, some of these winterizing tips can still be used. Ice can cause damage to the engine, road salt in the environment you are riding on can corrode the undercarriage of your ride, and extreme conditions can wreak havoc on your finely tuned machine. If you store your machine during the cold winter months, taking the time to properly maintain and prepare for storage can help avoid costly shop repairs and extend the life of your machine. Below are a few steps you can take to make sure your ATV, UTV, RTV, or Side By Side is in peak shape for the next riding season.

Tips To Winterize Your Machine

Our Tomahawk Tread in the Snow!

Thoroughly wash your ATV, UTV, RTV, or Side By Side. Good maintenance involves washing your machine after every use, however before storage it’s a good idea to give it an extra-thorough cleaning. Scrub every inch of your machine, maybe even using old toothbrush to get those hard to reach areas. Mud and oil can eat away at exposed surfaces over time. Once it’s dry, give it a good hand wax for added protection.

Change the oil and oil filter. Old oil contains acid from the combustion process, which over time, can attack internal components and cause corrosion. Changing the oil and filter before storage will also keep excess dirt from settling in your engine.

Grease suspension and drive components. An often-ignored item is the greasing of the pivot points in the suspension and steering systems. No manufacturer uses enough grease in the pivots to keep them trouble free for very long. A-arm bushings, swing arm pivots, and shock bushing/bearings all need to be lubricated to keep them working and prevent corrosion.

Disconnect and pull out the battery. Top off the electrolytes, clean the terminals and charge it if necessary. Store the battery in a location where it cannot freeze. It’s important to keep the battery stored out of the reach of children. Battery acid is dangerously corrosive. Store your ATV, UTV, RTV, or Side By Side’s battery on a high shelf or locked in a cabinet. Do not store it directly on concrete. Concrete causes power drain in batteries. Instead place the battery on top of a couple of 2×4 to keep it off the cement.

Clean and prep the air filter and wipe out the air filter box. Add some fuel stabilizer to the fuel tank and top off with fresh fuel. This reduces the surface area inside the fuel tank that can form condensation. For best results, use premium gasoline and run the engine a few minutes to allow the stabilizer to work its way through the fuel system. Shut off the engine, and turn off the gas valve. On carbureted ATV, UTV, RTV, or Side By Sides, turn off the petcock and restart the engine and run until it dies.  This will remove the fuel from the carburetor float bowl.

Lubricate all levers and cables to prevent corrosion and keep them moving smoothly.

Check your ATV, UTV, RTV, or Side By Side for loose hardware, lug nuts, steering linkage, suspension and motor mounts. Adjust and tighten as needed.

Remove the spark plugs and put a drop of motor oil into the spark plug hole and reinstall the spark plug to the manufacturers specification.

Check your recommended tire pressure on the sidewall of the tire, then check the pressure with a gauge. Make sure to pressurize the tires to the proper psi to keep them from weather cracking.

Cap the exhaust to keep critters out. To a small rodent, it looks like a nice, warm winter home.

It is not ideal for the machine to store your ATV, UTV, RTV, or Side By Side outside in winter climates. Push the machine into a shed or garage and place it up on blocks. Expensive jack stands aren’t necessary; cinder blocks or heavy plastic milk crates work just fine.

Place a tarp over the ATV, UTV, RTV, or Side By Side to keep excess dust and vermin away. If desired, leave an open can of auto wax on the floor under the tarp. The smell repels mice, chipmunks and other small pests.

For more information, check out ATV.com’s article: How To Winterize Your ATV or UTV.

Be sure to follow OTR Wheel Engineering, Inc. on the following sites:

Facebook | Twitter | Linkedin | InstagramAmazon Store | eBay

By | 2017-03-01T13:31:21+00:00 November 21st, 2016|Blog|1 Comment

One Comment

  1. jack November 30, 2017 at 4:16 pm - Reply

    Side by side ATV in winter can be done right?

Leave A Comment

FREE STANDARD SHIPPING TO THE LOWER 48 ON ALL ONLINE ORDERS! Dismiss